Urine Processing Assembly (UPA) Qualify Description Handbook/hb_vib... · 12/22/2011 ·...
Transcript of Urine Processing Assembly (UPA) Qualify Description Handbook/hb_vib... · 12/22/2011 ·...
−12
−11
−10
−9
−8
−7
−6
Σ PS
D M
agni
tude
[lo
g 10(g
2 /Hz)
]
GMT 13−December−2008, 348/hh:mm
Freq
uenc
y (H
z)
Start GMT 13−December−2008, 348/16:00:00
mams, hirapSpan = 8.00 hoursHanning, k = 3441
sum
Temp. Res. = 8.192 sec, No = 0Δf = 0.122 Hz, Nfft = 81921000.00 sa/sec (100.00 Hz)mams, hirap at LAB1O2, ER1, Lockers 3,4:[138.7 −16.2 142.3]
16:00 17:00 18:00 19:00 20:00 21:00 22:00 23:00 00:000
10
20
30
40
50
60
70
80
90
100
Description
Sensor HiRAP 1000.0 sa/sec (100.00 Hz)
Location LAB1O2, ER1, Lockers 3,4
Orientation Space Station Analysis (SSA)
Inc/Flight Increment: 18, Flight: ULF2
Plot Type Spectrogram
NOTES: The Urine Processing Assembly (UPA) was
installed in LAB1P4 during ULF-2 as part of the Water Recovery System (WRS).
The UPA contains 3 known potential microgravity disturbers: Distillation Assembly (DA) centrifuge, Fluids Control & Pump Assembly (FCPA) and the Pressure Control & Pump Assembly (PCPA).
MAMS HiRAP captured a DA centrifuge signature during a 5 hour run on GMT 348. The spectrogram on the left shows two distinct traces at 3.6 Hz and 33.3 Hz during this run. Data acquired from ISS telemetry confirms the DA centrifuge speed near 220 rpm.
No signature for PCPA is seen, which was known to be operating intermittently at 2500 rpm during the run. (~42 Hz).
Whether the FCPA was operating at this time was not determined.
Urine Processing Assembly (UPA) Qualify
PIMS ISS Acceleration Handbook Date last modified 12/22/11
Regime: Vibratory
Category: Vehicle
Source: Urine Processing Assembly
Microgravity Science Division Glenn Research Center
−12
−11
−10
−9
−8
−7
−6
Σ PS
D M
agni
tude
[lo
g 10(g
2 /Hz)
]
GMT 13−December−2008, 348/hh:mm
Freq
uenc
y (H
z)
Start GMT 13−December−2008, 348/16:00:00
mams, hirap020Span = 8.01 hoursHanning, k = 1091
sum
Temp. Res. = 24.381 sec, No = 0Δf = 0.041 Hz, Nfft = 4096168.00 sa/sec (20.00 Hz)mams, hirap020 at LAB1O2, ER1, Lockers 3,4:[138.7 −16.2 142.3]
16:00 17:00 18:00 19:00 20:00 21:00 22:00 23:00 00:000
2
4
6
8
10
12
14
16
18
20
Description
Sensor HiRAP 1000.0 sa/sec (100.00 Hz)
Location LAB1O2, ER1, Lockers 3,4
Orientation Space Station Analysis (SSA)
Inc/Flight Increment: 18, Flight: ULF2
Plot Type Spectrogram
NOTES: The spectrogram at the left is of HiRAP data
filtered at 20Hz, showing more clearly the 3.6 Hz operating frequency of the DA centrifuge.
The DA was designed with isolators used for
passive vibration isolation. By the time of the run on GMT 348, these isolators had been removed.
The WRS racks were be moved to Node 3 on
GMT 049/18-February-2010.
Urine Processing Assembly (UPA) Qualify
PIMS ISS Acceleration Handbook Date last modified 12/22/11
Regime: Vibratory
Category: Vehicle
Source: Urine Processing Assembly Microgravity Science Division Glenn Research Center
1 http://www.msnbc.msn.com/id/21134540/vp/18136150
Description
Sensor HiRAP 1000.0 sa/sec (100.00 Hz)
Location LAB1O2, ER1, Lockers 3,4
Inc/Flight Increment: 18, Flight: ULF2
Plot Type Cumulative RMS
NOTES: To quantify the impact of the DA
centrifuge operation, RMS accelerations are compared during centrifuge operation to those periods when it was off. The time periods chosen, were during crew sleep to help isolate the effects of the centrifuge from any vehicle modes.
The image below shows an undated photograph of the WRS racks on the ground. The DA is circled in orange.
Urine Processing Assembly (UPA) QUANTIFY
PIMS ISS Acceleration Handbook Date last modified 12/22/11
Regime: Vibratory
Category: Crew
Source: TVIS
Microgravity Science Division Glenn Research Center
0 20 40 60 80 100 120 140 160 1800
0.5
1
1.5
2
2.5
3x 10
−5
RM
S A
ccel
erat
ion
( g
RM
S )
Time (minutes) from: /misc/yoda/pub/pad/, $Name: $, 18−Dec−2008,22:29:22.056
Start GMT 13−December−2008, 348/16:00:00.000Urine Processing Assembly, 33.0 > f > 33.5 Hanning, k = 1
SSAnalysis[ 0.0 0.0 0.0]Increment: 18, Flight: ULF2
Temp. Resolution: 4.096 secΔf: 0.122 Hz, Range: 33 − 33.5 Hz1000.0000 sa/sec (100.00 Hz)mams, hirap at LAB1O2, ER1, Lockers 3,4:[138.68 −16.18 142.35]
0 50 100 1500
0.1
0.2
0.3
0.4
0.5
0.6
0.7
0.8
0.9
1x 10
−5 R
MS
Acc
eler
atio
n (
g R
MS
)
Time (minutes) from: /misc/yoda/pub/pad/, $Name: $, 18−Dec−2008,21:43:27.109
Start GMT 13−December−2008, 348/21:00:00.000Urine Processing Assembly 3.5 Hz < f < 3.7 Hz Hanning, k = 1SSAnalysis[ 0.0 0.0 0.0]
Increment: 18, Flight: ULF2
Temp. Resolution: 4.096 secΔf: 0.122 Hz, Range: 3.5 − 3.7 Hz1000.0000 sa/sec (100.00 Hz)mams, hirap at LAB1O2, ER1, Lockers 3,4:[138.68 −16.18 142.35]
Freq (Hz) RMS Acceleration
(g) OFF ON
3.5 -3.7 2.23 5.22 33.0 - 33.5 8.48 14.55
ON
ON
OFF
OFF