Raspberry shaped silicone powder “NH RAS06”...Raspberry shaped silicone powder “NH-RAS06”...
Transcript of Raspberry shaped silicone powder “NH RAS06”...Raspberry shaped silicone powder “NH-RAS06”...
Raspberry shaped silicone powder
“NH-RAS06”
Manufacturer:
IWASE COSFA
1
Raspberry shaped silicone powder
“NH-RAS06”-figure-
Cores : Raspberry shaped silicone powder
(process size : average of 0.5 μm)
Fine inorganic particle: alumina
(average of 0.2 μm)
2
Raspberry shaped silicone powder
“NH-RAS06”
✓Contact areas with the skin are smaller by Raspberry shaped, and to expand
texture than spherical particle.
✓Even if in alumina particle with high refractive index being contained, be
wetted by silicone Oils, not Soft focus effect damage.
✓Formability improvement effects of a foundation.
✓Cost effectively than others silicone powder.
INCI name POLYMETHYLSILSESQUIOXANE, ALUMINA
China Approved ( 聚甲基硅倍半氧烷、氧化铝)
Average
particle size
6 μm
Species Alumina inner silicone powder
Particle
shape
Raspberry shape
3
Introduction of raspberry shaped silicone powder
”NH-RAS06”
-Basic properties-
4
Raspberry shaped silicone powder
NH-RAS06
• Coefficient of dynamic friction (powdered bulk)
Measure of coefficient of mean friction(MIU) by friction
tester “KES-SE” (load 25 g, sensor: artificial leather) at
0.5mg/cm2 applied on artificial leather (IDEATEX JAPAN)
• Coefficient of dynamic friction (10% mixture with Talc)
Dispersed the sample to 10% in talc, and applied
0.5mg/cm2 in artificial leather (IDEATEX JAPAN). Measure
of coefficient of mean friction(MIU) by friction tester “KES-
SE” (load 25g, sensor : artificial leather).
5
resin
0
0.1
0.2
0.3
0.4
0.5
0.6
Talc NH-RAS06 Sphericalsilicone
resin
Confettishapedsilicone
PMMA Nylon-12
Spherical Powder 10% spherical powder with Talc
Coefficient of dynamic friction
Co
effic
ien
t of m
ean
frictio
n(M
IU)
Sample: various powder or mixing various spherical powder with Talc
Application quantity : 0.5mg/cm2 on artificial leather
Measuring equipment: KES-SE (load 25g, artificial leather sensor)
sm
oo
th
6
NH-RAS06 is smooth than other spherical powder, and good texture!
Raspberry shaped silicone powder
NH-RAS06
• Photodiffusion effect
Dispersed samples into 0.1% in oil solutions that prepared
refractive index, using triethylhexanoin and
phenyltrimethicone,and haze value is measured by
spectrophotometer (HITACHI U-3900 spectrophotometer) .
7
Photodiffusion effectMeasurement condition: sample 30% to oil solutions that refractive rate was
coordinated, coating film of 20 μm was measured.
NH-RAS06 shows high haze value at similar refractive index (1.5) with skin.
→ Excellent soft focus.
- - -NH-RAS06 spherical Silicone resin Confetti like Silicone resin
Tt: total transmitted light, Td: diffuse transmitted light
0
10
20
30
40
50
60
70
1.44 1.46 1.48 1.5
Td/T
t*1
00
(40
0n
m)
Refractive index
Short-wavelength (400nm)
0
10
20
30
40
50
60
70
1.44 1.46 1.48 1.5
Td/T
t*1
00
(70
0n
m)
Refractive index
Long-wavelength (700nm)
8
Film transmitted light
• Preparing dispersions of sample in below composition, and
prepare films of 20 μm on quartz plates. Prepared film was
taken at digital camera.
9
Composition (wt-%)
TRIMETHYLSILOXYSILICATE 10.0
ISODODECANE 40.0
PHENYLTRIMETHICONE 20.0
Sample 30.0
Film transmitted light
(Refractive rate 1.498)
NH-RAS06
Spherical Silicone
resin
Confetti shaped
Silicone resin
As be containing alumina particles, NH-RAS06 makes high soft-focus
effect comparisons others silicone resins!
10
NH-RAS06 -Basic Properties-
• Summary
✓NH-RAS06 is silicone powder which has smooth texture,
and is high soft focus effect.
✓ To high cost performance, the various product
applications.
Next, introduce of the application data !
11
Introduction of raspberry shaped silicone powder
NH-RAS06
-Lip color application-
12
Lip stick formulation
Component INCI Control Powder
A
1) Solid oils CERESIN, MICROCRYSTALLINE WAX 17.00 ←
2) Liquid oil
DIISOSTEARYL MALATE,
PENTAERYTHRITYL TETRAISOSTEARATE,
HYDROGENATED POLYDECENE
43.70 ←
3) Paste oil
DIPENTAERYTHRITYL
HEXAHYDROXYSTEARATE/STEARATE/ROSI
NATE
13.00 ←
4) Dispersing agent POLYGLYCERYL-2 TRIISOSTEARATE 20.20 15.20
B 5) Coloring pigmentIRON OXIDES, POLYGLYCERYL-2
TRIISOSTEARATE6.10 ←
C 6) Sample - 5.00
TOTAL 100 100
(wt-%)
13
Evaluations in cosmetics product
-Lip stick application-
- Adhesive property
Prepare Lipsticks including 5% various powders.
Attach Lipsticks to friction tester “KES-SE”, and applied it by speed of
1mm/sec on Bio-skin plates(BEAULAX) for 30 seconds.
- Glossiness
Prepare Lipsticks including 5% various powders.
Apply 1mg/cm 2 of lipsticks on artificial leather(IDEATEX JAPAN.
Measure gloss value by glossmeter (NIPPON DENSHOKU: angle of
incidence 20°).
14
Lipstick (Adhesive property)
Sample: powder 5% component or not mix
Measuring instrument: KES-SE, bio skin plate
NH-RAS06 is a good adhesion.
15
00.5
11.5
22.5
33.5
4
control NH-RAS06 Sphericalsilicone resin
Confettishaped
silicone resin
Ad
he
sive
pro
pe
rty[
mg]
Lipstick(Glossiness)
Sample : powder 5% component or not mix.
Measuring equipment : glossmeter(NIPPON DENSHOKU)
Measurement conditions : Applied 1mg/cm2 of Lipstick on the artificial leather.
NH-RAS06-blended is glossier than another silicone resin component.
16
0 200 400 600 800 1000 1200
control
NH-RAS06
Spherical silicone resin
Confetti shaped silicone resin
Evaluations in cosmetics product
-Lip stick application-
• Finish feeling
Made lipstick with NH-RAS06 5% and reference (no
powder). We will have it applied to the using to subject
normal case and lip in the same way, and checked finishes
feeling.
• Soft-focus effect evaluations
Lipstick that had supple various samples powders 5.0%
formulations. I applied so that various prototypes into
1mg/cm2 be turn in artificial leather(IDEATEX JAPAN), and
imaged appearance with digital camera .
17
Lipstick(Finish feeling)
Control NH-RAS06
NH-RAS06 has wrinkle blurring
effects, and colored finish in goods.
Also, regarding of lipstick was
improved in NH-RAS06's being
formulated, too
In the same way using normal case with lipstick application.
Appearance in the after coatings.
From good wrinkle blurring effects and color development,
lipstick on your lips a lot ?
18
0
1
2
3
4
5
6
7
8
control NH-RAS06
[Adhesive property]
Lipstick(Soft focus effect)Applied 1mg/cm2 of Lipstick on the artificial leather.
Control NH-RAS06Spherical
silicone resin
Confetti shaped
silicone resin
Even if same quantity is coated, it knows that as for soft
focus and color development, NH-RAS06-blended is superior.
In addition, compared with other Silicone resin looks vivid !
19
012345
Adhesion
Gloss
Finish
Wrinkle blurringeffect
Atached
Colordevelopment
Feeling of use
control
NH-RAS06
Lipstick(Evaluations by monitored testing)
• Evaluation method
Made a lipstick with NH-RAS06 5% and reference (no powder
formulation).
Check the usability of these lipsticks(n=6).
When NH-RAS06-blended is used, the wrinkle blurring effect, finish, and
more item quality assessment better than control !
20
Evaluations in cosmetics product
-Lip stick application-• Summary
✓NH-RAS06 is adhesived strength increases,
triming in feeling after use.
✓To soft focus with NH-RAS06, wrinkles
blurring effects are obtained.
✓Adhesions been high, and color development
become beautiful finish, too.
21
Introduction of raspberry shaped silicone powder
NH-RAS06
-Powder Foundation application-
22
Powder foundation formulation
Component INCI Control Powder
A
1) Plates powder TALC and METHICONE 76.86 68.06
2) White pigmentTITANIUM DIOXIDE, ALUMINUM
HYDROXIDE, HYDROGEN DIMETHICONE8.8 ←
3) Coloring pigment IRON OXIDES, HYDROGEN DIMETHICONE 2.25 ←
4) Preservative METHYLPARABEN 0.09 ←
5) Test powder - 8.8
B 6) Oily ingredients
DIMETHICONE, HYDROGENATED
POLYDECENE, PHYTOSTERYL
HYDROXYSTEARATE, NEOPENTYL
GLYCOL DIETHYLHEXANOATE,
TOCOPHEROL, PROPYLPARABEN
12.00 ←
TOTAL 100 100
(wt-%)
23
Evaluations in cosmetics product
-Powder Foundation applications-
• Coefficient of dynamic friction
Made measurement of coefficient of mean friction(MIU) by
friction tester “KES-SE” (load 25 g, sensor: artificial leather)
at 0.5mg/cm2 applied on artificial leather (IDEATEX JAPAN)
• Adhesive property
Various prototypes were on artificial leather (IDEATEX
JAPAN 1×4 cm2 5 times trips by puff token 5mg.
24
Powder foundation(coefficient of dynamic friction)Sample : control, Powder foundations with various spherical powder
8.8%.
Application quantity : 0.5mg/cm2 on artificial leather
Measuring equipment : KES-SE(load 25g, artificial leather sensor)
Powder foundation applied NH-RAS06 is good texture and smooth feeling.
25
sm
oo
th
Co
effic
ien
t of m
ean
frictio
n(M
IU)
0
0.1
0.2
0.3
0.4
0.5
0.6
control NH-RAS06 Spherical siliconeresin
Confetti shapedsilicone resin
Powder foundation (Adhesive property)
Control NH-RAS06 Spherical
silicone resin
Confetti
shaped
silicone resin
Live
photos
BINARY
PROCESS
Applied 5mg test foundations on the artificial leather.
NH-RAS06-blended of adhesion is good, compared with others samples.
26
Evaluations in cosmetics product
-applications to powder foundation-
• Photodiffusion effect
Dispersed samples into 0.1% in oil solutions that prepared
refractive rate, using triethylhexanoin and
phenyltrimethicone,and haze value is measured by
spectrophotometer (HITACHI U-3900 spectrophotometer) .
27
Powder foundation(Photodiffusion effect)
0
10
20
30
40
50
60
1.45 1.47 1.49
Td/T
t*1
00
(40
0n
m)
The refractive rate
Short-wavelength (400nm)
0
10
20
30
40
50
60
1.45 1.47 1.49
Td/T
t*1
00
(70
0n
m)
The refractive rate
Long-wavelength(700nm)
Measurement conditions : Dispersed 30% foundations to oil solutions that
refractive rate was controlled. Then the Haze value was measured by
spectrometer
NH-RAS06-blended of photodiffusion effect is big than other samples.
→Softfocus effect is excellent !
- - - -NH-RAS06 Spherical silicone resin Candy letter Silicone resin
Tt: full transmitted light, Td: diffuse transmitted light
Control
28
Evaluations in cosmetics product
-applications to powder foundation-
• Film transmitted light
Preparing dispersions of sample in below composition, and
prepare 20 μm films on quartz plates.
29
Component materials (wt-%)
TRIMETHYLSILOXYSILICATE 10.0
ISODODECANE 40.0
PHENYLTRIMETHICONE 20.0
Sample (foundations) 30.0
Powder foundation(Film transmitted light)
(Refractive index 1.498)
Control
NH-RAS06
Spherical silicone resin
Confetti shaped silicone
resin
A soft-focus effect of NH-RAS06’s foundation is higher than other foundation.
30
Powder foundation(Soft-focus effect)
Control
NH-RAS06
Spherical silicone resin
Confetti shaped silicone
resin
Applied 0.5mg/cm2 foundations on artificial leather.
31
A soft-focus effect of NH-RAS06’s foundation is higher than other foundation.
Evaluations in cosmetics product
-Powder foundation applications-
• Finish feeling
Test foundation: NH-RAS06 8.8%
Reference (no spherical powder)
After face wash, this product used with them in the
same way, and finished feeling be confirmed by
Robo-skin Analyzer RSA50 (Inforward).
32
Powder foundation(Finish feeling)In the application in the same way as using to subject normal case
roboskin analyzer after coatings sees how you like it.
When state of an application free was deemed to be 100%.
NH-RAS06’s Foundation hides pore compared to reference.
And it will be vividness looking.
33
0
20
40
60
80
100
120
not-apply control NH-RAS06
[%]
pores standing out
949698
100102104106108110112
not-apply control NH-RAS06
[%]
vividness
Powder foundation(Finish feeling)In the application in the same way as using to subject normal
case roboskin analyzer after coatings sees how you like it.
NH-RAS06’s foundation will be solidity and transparency
appearance.
Control
NH-RAS06
34
80
85
90
95
100
105
[mg]
Adhesive property
Powder foundation(evaluations by monitored testing)
• Evaluation method
This product used in 6 subjects in the same way, and carried out survey.
NH-RAS06 is a superior “blended pores blurring effects”,
“color development”, “feelings” than control.
35
012345
Adhesion
Finish
Pores blurringeffect
AtachedColor
development
Feeling of use
Texture
control
NH-RAS06
Evaluation of cosmetic preparation
-Powder foundation applications-
• Summary
✓NH-RAS06 give a application to smooth
texture by Raspberry-like shaped.
✓NH-RAS06 increase adhesion to the skin.
✓To soft focus with NH-RAS06, pores blurring
effects are obtained.
36
Raspberry shaped silicone powder
“NH-RAS06”
Key Points!
Smooth, Good adhesion, Soft- focus, Cost effectively
INCI name POLYMETHYLSILSESQUIOXANE, ALUMINA
China Approved ( 聚甲基硅倍半氧烷、氧化铝)
Average
particle size
6 μm
Species Alumina inner silicone powder
Particle
shape
Raspberry shape
37